Exova Warringtonfire, Frankfurt Industriepark Höchst, C369 Frankfurt am Main D-65926 Germany T : +49 () 69 35 3476 F : +49 () 69 35 1771 E : EBH@exova.com W: www.exova.com The qualification for testing according to 14 CFR 25.853 (a),(b) and (c) App. F Part I,II,V; 14 CFR Amdt. 25-83 has been established by LBA ref. No. M1-M117/227/1/.Test are performed acc. to new 14 CFR 25.853 Amdt. 25-116 and CS 25.853, no changes in test procedure for above mentioned tests are described in comparison to Amdt. 25-83. Prüfbericht / Test report Nr. / No. 216-133-1 vom / issued 24.5.216 Auftraggeber / Customer: ALFA Klebstoffe AG Kontakt / contact Vor Eiche 1 Ch 8197 Rafz Schweiz Auftragsdatum / Date of order: 31.3.216 + 2.5.216 Datum der Probenahme / keine offizielle Probennahme durch einen Date of sampling: Beauftragten von Exova Warringtonfire, Frankfurt no official sampling of the specimen by a representative of Exova Warringtonfire, Frankfurt Eingang der Proben / 4.4.216 + 4.5.216 Date of sample arrival Datum der Prüfungen / 6.4.216 + 2.5.216 Date of test: Auftrag / Order Prüfung der Brennbarkeit im Vertikaltest sowie Bestimmung der Rauchdichte und Toxizität an einem Prüfmuster unter Einwirkung von strahlender Wärme und Flammen. Testing burning behavior in the vertical test, the smoke density and the toxicity of a material under the influence of radiant heat and flames. Beschreibung / Bezeichnung des Prüfgegenstandes / Description / designation of the test object Probenmaterial bezeichnet als: Sample materials designated as: Beschreibung der zugrunde liegenden Prüfverfahren / Description of the relevant test procedures 12 sek. Vertikal-Test nach / 12 sec. Vertical Test in accordance with: - 14 CFR Part 25 25.853 (a) and Appendix F Part I, Amdt. 116 - CS-25.853 (a) and Appendix F Part I (a)(1)(ii), Amdt. 12, Change 17 - ABD31 Chapter 2.3.1, Issue G and Test Method AITM 2.2B issue 2 - D6-51377 Chapter 4.1, Issue F and Test Method BSS 723 Rauchdichte Test nach / Smoke Density Test in accordance with: - 14 CFR / CS Part 25 25.853 (d) and Appendix F Part V(b), Amdt. 116 - ABD31 Chapter 2.3.1, Issue G and Test Method AITM 2.7A - D6-51377 Chapter 4.1, Issue F and Test Method BSS 7238 Toxizitäts Test nach / Toxicity Test in accordance with: - ABD31 Chapter 2.3.2, Issue G and Test Method AITM 3.5 Issue 1 - D6-51377 Chapter 4.1, Issue F and Test Method BSS 7239 Registered Office: Exova GmbH, Industriepark Höchst, C369, Frankfurt, D-65926, Registered Company No. HRB 8349 Ust-Id Nr. DE259957713 1.6.216
Prüfbericht Nr. / Test report No. 216-133-1 vom / issued 24.5.216 Seite / page 2 von / of 6 1. Beschreibung des Probenmaterials / Description of the test material 1.1 Angaben des Auftraggebers / Details of the customer: Probenmaterial bezeichnet als: Sample materials designated as: Materialbeschreibung: Material Description: 9 x Muster 3.5 x 7.5 cm (228.75 cm 2 ) 9 x samples 3.5 / 7.5 cm (228.75 cm 2 ) Ø 6.39 g/228,75 cm2, Auftrag.279 g/cm 2. Ø 6.39 g/228,75 cm2, application.279 g/cm 2. (6.7 g, 6.5 g, 6.1 g, 6.5 g, 6.1 g, 6.4 g, 6.8 g, 6.1 g, 6.3 g) Ø = 6.39 g (6.7 g, 6.5 g, 6.1 g, 6.5 g, 6.1 g, 6.4 g, 6.8 g, 6.1 g, 6.3 g) Ø = 6.39 g 8 x Muster 7.5 x 7.5 cm (56.25 cm 2 ) 8 x samples 7.5 x 7.5 cm (56.25 cm 2 ) Ø 1.76 g/56.25 cm 2, Auftrag.313 g/cm 2. Ø 1.76 g/56.25 cm 2, application.313 g/cm 2. (2.1 g, 1.7 g, 1.8 g, 1.9 g, 1.5 g, 1.9, 1.7 g, 1.5 g) Ø = 1.76 g (2.1 g, 1.7 g, 1.8 g, 1.9 g, 1.5 g, 1.9, 1.7 g, 1.5 g) Ø = 1.76 g Vorgesehener Einsatzbereich des Produktes: Intended end use of product: Schaumstoffverklebung für Fluggastsitze Foam bonding for passenger seats 1.2 Bei der Probenvorbereitung durch Exova Warringtonfire, Frankfurt festgestellte Werte: 1.2 By Exova Warringtonfire, Frankfurt determined values: Kleber auf Metallblech / Glue on steel Farbe / Colour: Dicke / Thickness: Flächengewicht / Square weight: weiß / white 2,11 mm 2,25 mm 4,364 kg/m² Prüfung nach mindestens 24 Std. Klimalagerung bei 23 C und 5% rel. Luftfeuchte. Testing after climatic storage at 23 C and 5% rel. humidity for at least 24 h. 1.6.216
Prüfbericht Nr. / Test report No. 216-133-1 vom / issued 24.5.216 Seite / page 3 von / of 6 2.1 Versuchsergebnisse / Test results: 12 sek. Vertikal-Test nach / 12 sec. Vertical Test in accordance with: - 14 CFR Part 25 25.853 (a) and Appendix F Part I, Amdt. 116 - CS-25.853 (a) and Appendix F Part I (a)(1)(ii), Amdt. 12, Change 17 - ABD31 Chapter 2.3.1, Issue G and Test Method AITM 2.2B issue 2 - D6-51377 Chapter 4.1, Issue F and Test Method BSS 723 Proben aus Längsrichtung / specimen in lenght direction: Probe / sample Beflammungszeit ignition time Gesamtbrennzeit total burn time Nachbrennzeit after flame time Tropfen Anzahl number of drippings Tropfen Brennzeit drippings burn time Zerstörte Länge burn length [mm] 1 12 12 1 2 12 12 1 3 12 12 1 4 12 5 12 Grenzwert Limit 12,,,, 1, 15 5 23 Pass X Fail X 1.6.216
Prüfbericht Nr. / Test report No. 216-133-1 vom / issued 24.5.216 Seite / page 4 von / of 6 2.2 Versuchsergebnisse / Test results: Rauchdichte Test nach / Smoke Density Test in accordance with: - 14 CFR / CS Part 25 25.853 (d) and Appendix F Part V(b), Amdt. 116 - ABD31 Chapter 2.3.1, Issue G and Test Method AITM 2.7A - D6-51377 Chapter 4.1, Issue F and Test Method BSS 7238 Non flaming (NF) DS at (min) Sample no 1 2 3 4 5 6 Ds max bis 4 Min up to 4 min Bestanden 14 ABD CFR 1 1 1 2 5 6 6 5 ja ja 2 8 1 14 19 23 14 yes yes 3 1 5 11 18 26 11 Max Wert Max Value 1 8 1 14 19 26 3 6 1 14 19 Flaming (F) DS at (min) Sample no 1 2 3 4 5 6 Ds max bis 4 Min up to 4 min Bestanden 14 ABD CFR 1 1 31 47 66 88 14 66 ja ja 2 9 39 57 79 12 125 79 yes yes 3 7 22 44 68 97 44 Max Wert Max Value 9 39 57 79 12 125 4 26 42 63 86 19 Bemerkungen: Remarks: 1.6.216
Prüfbericht Nr. / Test report No. 216-133-1 vom / issued 24.5.216 Seite / page 5 von / of 6 2.3 Versuchsergebnisse / Test results: Toxizitäts Test nach / Toxicity Test in accordance with: - ABD31 Chapter 2.3.2, Issue G and Test Method AITM 3.5 Issue 1 - D6-51377 Chapter 4.1, Issue F and Test Method BSS 7239 Gas Gas Limit after 4 Min Non Flaming (NF) Flaming (F) (ppm) Sample no. Sample no. Hydrogen 15 1 1 Cyanide HCN 2 2 3 3 Carbon 1 1 1 1 Monoxide CO 2 2 1 3 3 1 Nitrous Gases 1 1 1 NO-NO2 2 2 3 3 Sulfur Dioxide 1 1 15 1 15 Hydrogen Sulfide 2 15 2 15 SO2-H2S 3 15 3 15 15 Hydrogen 1 1 1 Fluoride HF 2 2 3 3 Hydrogen 15 1 1 Chloride HCL 2 2 3 3 1 15 1.6.216
Prüfbericht Nr. / Test report No. 216-133-1 vom / issued 24.5.216 Seite / page 6 von / of 6 3. Beurteilung / Assessment Das in Abschnitt 1 beschriebene Material erfüllt die Anforderungen: The material described in chapter 1 fulfils the requirements: 12 sek. Vertikal-Test nach / 12 sec. Vertical Test in accordance with: - 14 CFR Part 25 25.853 (a) and Appendix F Part I, Amdt. 116 - CS-25.853 (a) and Appendix F Part I (a)(1)(ii), Amdt. 12, Change 17 - ABD31 Chapter 2.3.1, Issue G and Test Method AITM 2.2B issue 2 - D6-51377 Chapter 4.1, Issue F and Test Method BSS 723: Rauchdichte Test nach / Smoke Density Test in accordance with: - 14 CFR / CS Part 25 25.853 (d) and Appendix F Part V(b), Amdt. 116 - ABD31 Chapter 2.3.1, Issue G and Test Method AITM 2.7A - D6-51377 Chapter 4.1, Issue F and Test Method BSS 7238 Toxizitäts Test nach / Toxicity Test in accordance with: - ABD31 Chapter 2.3.2, Issue G and Test Method AITM 3.5 Issue 1 - D6-51377 Chapter 4.1, Issue F and Test Method BSS 7239 ja/yes ja/yes ja/yes 4. Besonderer Hinweis / Special note Das Brandversuchsergebnis gilt für das in Abschnitt 1 beschriebene Material. The fire test result is only valid for the material described in chapter 1. Im Verbund mit anderen Materialien (z.b. Beschichtungen, Hinterlegungen) kann das Brandverhalten ungünstig beeinflusst werden, so dass die o. a. Klassifizierung nicht mehr gültig ist. Das Brandverhalten des Materials im Verbund mit anderen Materialien ist gesondert nachzuweisen. If combined with other materials the burning behaviour can be influenced unfavourably so that the classification above is not valid any more. The burning behaviour in composition with other materials has to be tested separately. Dieser Prüfbericht ersetzt den Prüfbericht 216-133 vom 24.5.216 (Datum der Unterschrift), der hiermit ungültig wird. This test report replace the test report 216-133 issued 24.5.216 (date of signature), which is invalid from now on. Frankfurt, den / the 9.6.216 H. Anders / H. Schmid Dipl.-Ing. T. Zachäus Verantwortlicher Prüfer Laborleiter Tester in charge Laboratory Supervisor Die Ergebnisse der Prüfungen beziehen sich ausschließlich auf den oben bezeichneten Prüfgegenstand. Prüfberichte dürfen ohne Zustimmung von Exova Warringtonfire, Frankfurt nur nach Form und Inhalt unverändert veröffentlicht oder vervielfältigt werden. Die gekürzte Wiedergabe eines Prüfberichts ist nur mit Zustimmung von Exova Warringtonfire, Frankfurt zulässig. Dieser Prüfbericht umfasst 6 Seiten. These test results relate only to the behavior of the test specimens under the particular conditions of the test. They are not intended to be the sole criterion for assessing the potential fire hazard of the product in use. Test reports are only allowed to be published or reproduced, not changed in form and tenor without permission of Exova Warringtonfire, Frankfurt. The abridged account of a test report is only allowed with the agreement of Exova Warringtonfire, Frankfurt. This test reports contains 6 pages. 1.6.216